欢迎访问《核聚变与等离子体物理》官方网站,今天是 分享到:

核聚变与等离子体物理 ›› 2010, Vol. 30 ›› Issue (2): 178-182.

• 等离子体应用 • 上一篇    下一篇

射频等离子体制备球形钨粉研究

古忠涛,叶高英,刘川东,童洪辉   

  1. (核工业西南物理研究院,成都 610041)
  • 收稿日期:2009-08-04 修回日期:2010-03-18 出版日期:2010-06-15 发布日期:2010-06-03
  • 作者简介:古忠涛(1971-),男,四川安县人,博士研究生,工程师。

Study on the techniques with using of RF induction plasma for tungsten powders spheroidization

GU  Zhong-tao,YE  Gao-ying,LIU  Chuan-dong,TONG  Hong-hui   

  1. (Southwestern Institute of Physics, Chengdu 610041)
  • Received:2009-08-04 Revised:2010-03-18 Online:2010-06-15 Published:2010-06-03

摘要: 采用射频(RF)等离子体对颗粒形状不规则的钨粉球化,研究了加料速率和钨粉分散方式对球化率的影响。通过用电子扫描显微镜(SEM)观测得到的被球化粉末的百分比评估了球化效率。通过对球化处理的钨粉的X射线衍射谱(XRD)的检测,验证了在球化过程中无氧化发生和其它杂质介入。当钨粉以极短暂时间(约几毫秒)快速穿越等离子体炬时,钨粉颗粒因受热而熔化成液滴,快速冷却后,形成致密的球形固态颗粒。

关键词: 射频等离子体, 球化, 钨粉

Abstract: Spherical tungsten particles were obtained by the process of heating irregularly shaped tungsten powders under radio frequency induction plasma (RF induction plasma) condition. The effect of feed rate and different disperse ways on spheroidization efficiency was studied. The efficiency of the spheroidization is evaluated through measurements of the percentage of powder spheroidized based on sweep electron microscopic SEM observations. After detection of the XRD of spheroidized tungsten powder, non-oxidation and no other impurity are verified in the preparation process. During the short flight of the tungsten particles in the plasma flow, about the order of a few milliseconds, the individual particles of the tungsten powder are heated and melted forming a spherical liquid droplet which upon freezing gives rise to the formation of a perfectly dense spherical solid particle.

Key words: Radio frequency induction plasma, Spheroidization, Tungsten powder

中图分类号: